全自動自上料攪拌車攪拌軸停轉我們?cè)趺刺幚恚?/h3>  來源：http://www.ym250.cn 日期：2020-08-07 發布人：admin

1.這種現象主要是由于以下幾種原因，，全自動自上料攪拌車運轉超載，全自動自上料攪拌車超載可以造成其自身負荷過大，攪拌軸的攪拌速度變緩，導致攪拌機的攪拌效果降低。

1. This phenomenon is mainly due to the following reasons: concrete mixer overload, concrete mixer overload can cause its own load is too large, the mixing speed of mixing shaft becomes slow, resulting in the mixing effect of mixer is reduced.

2.全自動自上料攪拌車非常容易出現停轉或過負損壞現象，第二，攪拌葉片與側葉片與罐內壁間有大的異物，攪拌機在攪拌的過程中非常容易出現異物卡塞現象。

2. The concrete mixer is very easy to stop running or over negative damage. Secondly, there are large foreign matters between the mixing blade and the side blade and the inner wall of the tank, which makes it easy for the mixer to jam during the mixing process.

3.當較大的異物處于攪拌葉片或側葉片與罐內壁之間時，兩者正常運轉非常容易受到限制，出現停滯現象，或側葉片與罐內壁間隙過大時這種現象發生率非常高。

3. When the large foreign matter is between the mixing blade or the side blade and the inner wall of the tank, the normal operation of the two is very easy to be restricted and stagnant, or when the clearance between the side blade and the inner wall of the tank is too large, the occurrence rate of this phenomenon is very high.

4.全自動自上料攪拌車在使用的過程中非常容易出現電機膠帶震動松動現象，這種松動導致全自動自上料攪拌車的傳輸動力大打折扣，造成無法完成負荷攪拌操作。

4. In the process of using the concrete mixer, it is very easy to loose the motor belt vibration, which leads to the transmission power of the concrete mixer greatly reduced, resulting in the failure to complete the load mixing operation.

5.在對攪拌葉片與側葉片與罐內壁間有大的異物進行處理的過程中，操作人員要對出現的摩擦聲進行分析，當出現尖銳、刺耳聲音時要及時停止，對攪拌機進行停機檢查，觀察故障位置，對異物進行清理。

5. In the process of handling the large foreign matters between the mixing blade and the side blade and the inner wall of the tank, the operator shall analyze the friction sound, stop the mixer in time when there is sharp and harsh sound, stop the mixer for inspection, observe the fault position and clean up the foreign matters.

本文由攪拌機整理發布，您是不是對這些內容有所了解了呢?更多的內容請點擊：http://www.ym250.cn我們會有更多精彩內容等你查看。

This article is organized and released by Zhongke Jufeng mixer. Do you have any understanding of these contents? For more information, please click: http://www.ym250.cn We'll have a lot more to see.

上一篇：自上料混凝土攪拌罐車輪胎保養應該注意些什么？
下一篇：攪拌車混凝土離析與什么原因有關？